Services
Every job we do on electric cars, system by system
The work we do on electric cars, grouped by system. Each page explains the symptoms, what we check and what we repair. Not sure where your problem fits? Send it on WhatsApp with the model and year.
System map
Start from the system
Illustration: a generic electric-car chassis seen from above, not any particular make or model.
Pick a system
Tap a numbered system on the drawing or in the list to see the work we do on it, then message us about it.
System 1
Drive unit & motor
Motor bushes, drive-unit isolation faults and drive-unit oil.
Common symptoms
- A clunk from the rear when you accelerate or lift off
- A drive-unit or isolation warning on the screen
What we check
- Noise on a road test and on the lift
- Motor mounts and bushes
- Isolation readings and fault codes
What we do
- Motor bush replacement
- Drive-unit isolation repair
- Drive-unit oil service
System 2
HV battery & power electronics
Contactors, PCS and pyro fuse replacement, with the programming the car needs.
Common symptoms
- The car will not go into drive after a warning
- Charging stops or the charge port shows a fault
What we check
- High-voltage warnings and fault codes
- Contactor and PCS operation
What we do
- Contactor replacement
- PCS replacement
- Pyro fuse replacement
- Programming after the repair
System 3
Cooling & radiator
Radiator deep cleaning or replacement, coolant flush and water pumps.
Common symptoms
- A coolant or fan warning in summer heat
- The fans run loudly for a long time after a drive
What we check
- Radiator and condenser condition
- Coolant level, leaks and pump operation
What we do
- Radiator deep cleaning
- Radiator replacement
- Coolant flush
- Water pump replacement
System 4
AC & heat pump
Compressor, condenser, cabin filters, gas refill and system flushing.
Common symptoms
- The AC blows warm air
- A musty smell from the vents
What we check
- Refrigerant pressure and leaks
- Compressor and condenser operation
What we do
- Compressor replacement
- Condenser replacement
- Cabin filter replacement
- Gas refill and system flushing
System 5
Suspension & steering
Control arms, links, knuckles, bushes and steering racks.
Common symptoms
- Knocking over bumps
- The steering feels loose or pulls to one side
What we check
- Play in the arms, links and bushes on the lift
- Steering rack and tie rods
What we do
- Control arms and links
- Knuckles and bushes
- Steering rack
System 6
12V / 16V battery
Low-voltage battery replacement, reset and configuration.
Common symptoms
- A 12V or low-voltage battery alert
- The car will not wake up or unlock
What we check
- Battery health and charging from the car
What we do
- 12V / 16V battery replacement
- Reset and configuration
- Battery unlock where the car needs it
System 7
Software & diagnostics
Software updates on VW ID. models, and diagnosis of warning messages.
Common symptoms
- An update is needed or failed
- A warning message you cannot clear
What we check
- Fault codes and module software versions
What we do
- Software updates on the VW ID.4 and ID.6
- Programming after high-voltage repairs
- Diagnosis of warning messages
Start here
Scheduled service & inspection
Minor and major services and standard inspections for electric cars.
What we do
- Minor and major service
- Standard inspection
Drive and high voltage
The parts that move the car and manage its high-voltage power.
-
Drive unit & motor repair
Motor bush replacement, drive-unit isolation faults and drive-unit oil changes.
-
HV battery & power electronics
Contactor, PCS and pyro fuse replacement, with the programming the car needs afterwards.
-
Software updates & programming
Software updates for the VW ID.4 and ID.6, and programming after high-voltage repairs.
Heat: AC and cooling
The systems that work hardest in a UAE summer.
Chassis
Heavy batteries and strong torque load the suspension, steering and brakes.
Electrics and faults
Low-voltage power, warnings and faults that come and go.
Checks and reports
Before you buy, sell or hand a car back.
Hybrid cars
The same high-voltage skills, applied to hybrids.
For companies
Electric and hybrid cars in company fleets.
FAQ
Questions owners ask
Which cars do you work on?
Tesla Model 3, Model Y, Model S and Model X, Volkswagen ID.4 and ID.6, and BYD Han and Dolphin. For other electric cars, send the make, model and year on WhatsApp and we will tell you whether we can help.
Do you do manufacturer recalls?
No. Recall repairs are free at the manufacturer, so check your VIN with Tesla, Volkswagen or BYD before paying for a repair on a recalled part.
Do you work with company fleets?
Yes: company accounts with monthly invoicing and priority booking. See company fleets.
Not sure which service you need?
Describe what the car is doing on WhatsApp, with the model and year. A photo or short video helps.